DOUBLET, among lapidaries, implies a counterfeit stone, composed of two pieces of crystal, and sometimes glass softened, together with proper colours between them; so that they make the same appearance to the eye as if the whole substance of the crystal had been tinged with these colours.
The impracticability of imparting tinges to the body of crystals, while in their proper and natural state, and the softness of glass, which renders ornaments made of it greatly inferior in wear to crystal, give inducements to the introduction of colouring the surface of crystal wrought in a proper form, in such a manner, that the surfaces of two pieces so coloured being laid together, the effect might appear the same as if the whole surface of the crystal had been coloured. The crystals, and sometimes white transparent glass so treated, were called doublets; and at one time prevailed greatly in use, on account of the advantages, with respect to wear, such doublets had, when made of crystal, over glass, and the brightness of the colours which could with certainty be given to counterfeit stones this way, when coloured glass could not be procured, or at least not without a much greater expence. Doublets have not indeed the property which the others have, of bearing to be set transparent, as is frequently required in drops of ear-rings and other ornaments: but when mounted in rings, or used in such manner that the sides of the pieces where the joint is made, cannot be inspected, they have, when formed of crystal, the title to a preference to the coloured glass; and the art of managing them is therefore, in some degree, of the same importance with that of preparing glass for the counterfeiting gems; and is therefore properly an appendage to it, as being entirely subservient to the same intention. The manner of making doublets is as follows:
Let the crystal or glass be first cut by the lapidaries in the manner of a brilliant, except that, in this case, the figure must be composed from two separate stones, or parts of stones, formed in the manner of the upper and under parts of a brilliant, if it was divided into a horizontal direction, a little lower than the middle. After the two plates of the intended stone are thus cut, and fitted so exactly that no division can appear when they are laid together, the upper part must be polished ready for setting; and then the colour must be put betwixt the two plates by this method. "Take of Venice or Cyprus turpentine two scruples; and add to it one scruple of the grains of mastich chosen perfectly pure, free from foulness, and previously powdered. Melt them together in a small silver or brass spoon, ladle, or other vessel, and put to them gradually any of the coloured substances mentioned below, being first well powdered; stirring them together as the colour is put in, that they may be thoroughly commixed. Warm then the doublets to the same degree of heat as the melted mixture; and paint the upper surface of the lower part, and put the upper one instantly upon it, pressing them to each other, but taking care that they may be conjoined in the most perfectly even manner. When the cement or paint is quite cold and set, the redundant part of it, which has been pressed out of the joint of the two pieces, should be gently scraped off the side, till there be no appearance of any colour on the outside of the doublets; and they should then be skilfully set; observing to carry the mounting over the joint, that the upper piece may be well secured from separating from the under one.
The colour of the ruby may be best imitated, by mixing a fourth part of carmine with some of the finest crimson lake that can be procured.